winshield closing issue

[JMVOTTO]

anyone have a problem with the center windshield binding at the top . this is a new 2017 lsv with 30 hrs on it . all screws and brackets look fine.

 

[Raimie]

Same issue on my 2018 T22

[vanamp]

5 minutes ago, Raimie said:

Same issue on my 2018 T22

Mine hits a little too but only sometimes. On the top corner.

[Raimie]

2 minutes ago, vanamp said:

Mine hits a little too but only sometimes. On the top corner.

Ya, must depend on humidity or something because it doesn't always do it.

[Agman]

Same here ‘17 T23

[Fman]

I had a similar issue with my lsv when I took delivery.  My windshield was flexing and binding up while towing a wakeboarder.   It ended up being the U bar bolts were never tightened.  There also should be some shims installed.  Take a look at the attached doc.  It might not relate to Axis and your problem but who knows maybe it will help you guys out.

At very least you can check your U bar bolts.

Edited June 12, 2018 by Fman

[JMVOTTO]

thx Fman

never had this issue on my other mfg for 10 yrs  2 different models.

 

 

 

Edited June 12, 2018 by JMVOTTO

[Dwake]

My 2018 lsv same issue with windshield.  Got to push left on left side of windshield  and it pops in

[Fman]

17 hours ago, Dwake said:

My 2018 lsv same issue with windshield.  Got to push left on left side of windshield  and it pops in

You should check you Ubar bolts and shims...will be interesting to see if that is the problem?

[Pnwrider]

On 6/14/2018 at 4:25 PM, Dwake said:

My 2018 lsv same issue with windshield.  Got to push left on left side of windshield  and it pops in

My 18 lsv showed up misaligned as well...

[JMVOTTO]

First look mine are loose   I can spin washers by hand.   Didn’t have time to mess with it. It was surf time 

[Raimie]

I didn't have a chance to inspect, but I did have my dealer look at it when I took my boat in for the 20 hr service. They mentioned that a replacement windshield was required (under warranty) and that it was installed wrong at the factory. I'm puzzled why a new windshield would be required, but as long as its getting fixed, I guess I'm ok with it. I will put this off until winter, however.

Edited June 29, 2018 by Raimie

[23LSVOwner]

2 hours ago, Raimie said:

I didn't have a chance to inspect, but I did have my dealer look at it when I took my boat in for the 20 hr service. They mentioned that a replacement windshield was required (under warranty) and that it was installed wrong at the factory. I'm puzzled why a new windshield would be required, but as long as its getting fixed, I guess I'm ok with it. I will put this off until winter, however.

Replacement?

 

From the post it seems to me like it could be adjusted/relocated.

[Raimie]

21 minutes ago, 23LSVOwner said:

Replacement?

 

From the post it seems to me like it could be adjusted/relocated.

Agree completely. I was in a hurry when I had the discussion with them but plan to discuss more in the fall. I'll post an update on it when I have more info.